全自動攪拌車廠家講解雨季如何保養設備
溫度漸漸上升，夏天要來了！所以可想而知，雨季要開始了，那么這個時候全自動攪拌車的車主要注意給設備做好雨季保養工作了，不然非常可能會因?yàn)檫M(jìn)水而造成設備的損壞。下面我們就來講講吧。
The temperature is gradually rising, summer is coming! Therefore, it is conceivable that the rainy season is about to begin. At this time, the car of the automatic mixer mainly pays attention to the maintenance of the equipment in the rainy season, otherwise it is very likely to cause damage to the equipment because of the water. Let's talk about it.
由于全自動攪拌車在室外停放的時間比較長，所以在夏雨中直接陣雨的機會較多。然而，今天的雨水中含有越來越多的酸性物質。為防止隨車吊的防護漆被雨水侵蝕雨后應立即清洗隨車吊，并對設備表面的漆層進行綜合保養。
Because the automatic mixer parked in the outdoor for a long time, so in the summer rain direct shower more opportunities. Today, however, rain contains more and more acid. To prevent the protective paint of the truck crane from being eroded by rain, the truck crane should be cleaned immediately after rain, and the paint layer on the surface of the equipment should be comprehensively maintained.
全自動攪拌車內部的電氣裝置通常容易受到夏雨帶來的濕氣的影響，造成漏電等小故障，給全自動攪拌車的啟動和使用帶來不便。因此，建議您在雨天使用專用干燥劑等物質噴灑在電線、火花塞、高壓線等易出故障的部位，使其保持干燥。
The electric device inside the automatic mixer is usually susceptible to the influence of moisture brought by summer rain, resulting in small faults such as leakage, which brings inconvenience to the start and use of the automatic mixer. Therefore, it is recommended that you use special desiccant and other substances sprayed in the wire, spark plug, high voltage line and other prone to failure parts, so that it stays dry.
攪拌車出水后檢查發動機：檢查攪拌車缸內是否有水。進水會導致連桿彎曲，損壞攪拌車發動機。檢查攪拌車油中是否有水。油中的水分會使油變質，失去潤滑作用，造成攪拌機發動機過度磨損。檢查攪拌車變速箱是否有水。齒輪箱內的水會使齒輪箱內的齒輪油變質，造成齒輪磨損。檢查攪拌車的剎車油和四輪剎車。剎車油中的水會使剎車油變質，導致剎車失靈。
Check the engine after the water comes out of the mixer truck: first check whether there is water in the cylinder of the mixer truck. Water can cause the connecting rod to bend and damage the mixer engine. Check if there is water in the mixer oil. The moisture in the oil will make the oil deteriorate and lose lubrication, resulting in excessive wear of the mixer engine. Check the mixer gearbox for water. Water in the gear box will make the gear oil in the gear box deteriorate, causing gear wear. Check the mixer's brake oil and four-wheel brakes. Water in the brake oil can deteriorate the brake oil and cause the brakes to fail.
全自動攪拌車廠家認為，如果有水進入排氣管，應盡快將積水排掉，以免水中的雜質堵塞三元催化器或損壞氧傳感器。檢查攪拌車電瓶是否充滿水，必要時更換電瓶。對于變速箱車，檢查攪拌車變速箱和變速箱控制電腦是否進水?？鞂⒔菰跀嚢铏C(jī)中的物品（座套、腳墊等）擦干，以免發霉。
Automatic mixer truck manufacturers believe that if there is water into the exhaust pipe, the water should be drained as soon as possible, so as not to block the impurities in the water three catalytic converter or damage the oxygen sensor. Check whether the battery of the mixer truck is full of water and replace the battery if necessary. For transmission vehicles, check the mixer transmission and transmission control computer for water. Quickly dry the items (seat covers, floor MATS, etc.) soaked in the blender to avoid mildew.
另外，無論是地面上的積水、污泥還是從空中落下的雨水，其帶來的濕氣很容易造成全自動攪拌車底盤等金屬部件的腐蝕。所以建議大家做好完善的清潔防銹處理。更多內容就來網站ablank.cn咨詢吧！
In addition, whether the water on the ground, sludge or rain falling from the air, the moisture is easy to cause corrosion of metal parts such as the chassis of the automatic mixer truck. Therefore, it is recommended that we do a good job of cleaning and rust prevention treatment. More content to the website ablank.cn consultation!
