混凝土自上料攪拌車氣路系統的五點重要維護
像一些泥土之類的，需要混凝土自上料攪拌車邊攪拌邊運輸，泥土含有一定的水分，一旦水分少了它就會變干，因此需要在運輸過程中慢慢攪拌，氣路系統作為攪拌車常用的一種部件，攪拌車的氣路系統的保養應該怎么做？混凝土自上料攪拌車廠家為您講解五點。
For example, some soil needs to be transported while mixing from the loading mixer. The soil contains a certain amount of water. Once the water is less, it will become dry. Therefore, it needs to be mixed slowly during the transportation. As a commonly used component of the mixer, how should the air system of the mixer be maintained? The manufacturer of concrete self loading mixer will explain five points to you.
1、混凝土自上料攪拌車空氣壓縮機應水平放置、固定，通風良好。
1. The air compressor of the concrete self loading mixer shall be placed horizontally, fixed and well ventilated.
2、不能經受風吹雨淋，也不能暴曬在陽光下。
2. It shall not be exposed to the wind, rain or sun.
3、調整好空氣壓力自動開關的上下限值，壓力過低會導致氣缸動作遲緩，壓力過高對氣路系統密封件不利。
3. Adjust the upper and lower limits of the automatic air pressure switch. If the pressure is too low, the cylinder will act slowly. If the pressure is too high, it will be harmful to the seals of the air circuit system.
4、檢查混凝土自上料攪拌車潤滑油的油位，保持油面在油尺上下線之間，油面接近下線時，添加新油。
4. Check the oil level of the lubricating oil from the concrete feeding mixer truck, keep the oil level between the upper and lower lines of the dipstick, and add new oil when the oil level is close to the lower line.
5、檢查傳送帶張力是否合適，當用手指壓皮帶，皮帶下陷10mm左右為宜；更換傳送帶時應整組更換，以保持張緊度一致。
5. Check whether the belt tension is appropriate. When pressing the belt with fingers, the belt should sink about 10mm; When replacing the conveyor belt, replace the whole group to keep the same tension.
氣路系統對于混凝土自上料攪拌車來說也是一處重要的部件，需要添加充足的油，并且保持油量充足，足夠攪拌車的運行，在提高攪拌車的使用效率的同時，也能加強對氣路系統的保養。上述講解內容希望能夠給您幫助，更多注意事項就來我們網站http://ablank.cn進行咨詢了解吧！
The air passage system is also an important part of the concrete self feeding mixer truck. It is necessary to add enough oil and keep the oil sufficient to run the mixer truck. While improving the use efficiency of the mixer truck, it can also strengthen the maintenance of the air passage system. I hope the above explanations can help you. Please come to our website for more precautions http://ablank.cn Consult and understand!
下一篇：攪拌車在操作之前的五個檢查方面上一篇：自上料攪拌車的使用能干什么
