攪拌車各項部件的檢查事項
攪拌車制動液面的檢查
Inspection of brake fluid level of mixer truck
制動也在高、低位之間則表示正常。如果制動液接近下限或低于下限則表示系統中可能有泄漏或制動蹄片磨損過多,應及時到維修站進行檢修。補加制動液時,要注意加同一種型號的制動液,防止損壞皮碗,注意保護好油漆防止腐蝕漆面。
If the braking is also between high and low, it means normal. If the brake fluid is close to or lower than the lower limit, it indicates that there may be leakage in the system or the brake shoe is worn too much, and it should be repaired at the maintenance station in time. When adding brake fluid, pay attention to adding the same type of brake fluid to prevent damage to the leather cup, and pay attention to protect the paint to prevent corrosion of the paint surface.
攪拌車離合器總泵液面的檢查
Inspection of liquid level of clutch master cylinder of mixer truck
攪拌車離合器液面介于高、低液面間則表示正常,如果低于標準線,則可能是總泵或分泵皮碗損壞。在發動機運行狀態下將出現掛檔難或無法掛檔的現象,請即時到就近的維修站檢修。
If the liquid level of the mixer truck clutch is between high and low, it indicates that it is normal. If it is lower than the standard line, it may be that the master cylinder or the slave cylinder cup is damaged. It will be difficult or impossible to shift when the engine is running. Please go to the nearest maintenance station for maintenance immediately.
攪拌車的蓄電池的保養檢查
Maintenance and inspection of mixer battery
檢查蓄電池固定是否牢固,電解液應在上限和下限之間,接近下線時應及時補加電解液或蒸餾水高位線。保持蓄電池正負電纜接觸良好,并保持蓄電池清潔干燥。放置時間較長的攪拌車要摘下蓄電池的正負極電纜,相隔半個月左右重新接線起動攪拌車發動機約20分鐘后,如果電量明顯不足要及時充電。
Check whether the battery is firmly fixed. The electrolyte should be between the upper limit and the lower limit. When it is close to the offline, add electrolyte or distilled water to the high level line in time. Keep the positive and negative cables of the battery in good contact, and keep the battery clean and dry. For the mixer truck that has been placed for a long time, the positive and negative cables of the battery should be removed, and the wires should be reconnected after about half a month. After starting the engine of the mixer truck for about 20 minutes, if the power is obviously insufficient, it should be charged in time.
攪拌車輪胎的檢查
Inspection of mixer tires
每月應在常溫下檢查一下輪胎氣壓,如果低于正常標準應及時補充輪胎氣壓。氣壓不能過高或過低,否則影響駕駛的性。檢查攪拌車輪胎的龜裂情況,存在隱患時應及時更換輪胎。選用輪胎時,應使之型號一致。
Check the tire pressure at normal temperature every month. If it is lower than the normal standard, supplement the tire pressure in time. The air pressure should not be too high or too low, otherwise it will affect the safety of driving. Check the cracking of the mixer truck tires, and replace the tires in time when there are potential safety hazards. When selecting tires, make them the same model.
皮帶的檢查
Inspection of belt
起動攪拌車發動機或平時駕駛車輛時,皮帶發響,全自動攪拌車廠家認為一種情況是皮帶長期沒有檢查調整造成,按正常標準調整即可。另一種情況是皮帶老化,需更換。
When starting the mixer engine or driving the vehicle at ordinary times, the belt makes a noise. The manufacturer of the full-automatic mixer believes that one situation is that the belt has not been checked and adjusted for a long time, and it can be adjusted according to the normal standard. The other is that the belt is aging and needs to be replaced.
空氣濾清器的檢查
Inspection of air filter
空氣濾清器過臟會引起攪拌車發動機工作不良、油耗過大,損壞發動機等,檢查空氣濾清器時,若發現灰塵較少,堵塞較輕,可用高壓空氣從內向外吹凈,繼續使用。過臟的空氣濾清器應及時更換。九、攪拌車火花塞的檢查正常的攪拌車火花塞絕緣陶瓷完好。沒有破裂漏電現象,火花塞間隙0.8+-0.0mm放電時,火花呈藍色,較強。若發現異常需進行調整間隙或更換火花塞。
Dirty air filter will cause poor operation of mixer engine, excessive fuel consumption, engine damage, etc. when checking the air filter, if less dust and light blockage are found, high-pressure air can be used to blow it out from inside to outside and continue to use. The dirty air filter should be replaced in time. 9、 Check the spark plug of the mixer truck. The insulating ceramics of the spark plug of the normal mixer truck are intact. There is no crack and leakage. When the spark plug gap is 0.8+-0.0mm, the spark is blue and strong. If any abnormality is found, adjust the gap or replace the spark plug.
檢查攪拌車油濾清器
Check the oil filter of the mixer truck
若發現供油不暢應檢查汽油濾清器是否堵塞,如異物堵塞應及時更換。更多相關信息就來網站http://ablank.cn聯系我們咨詢吧！
If it is found that the fuel supply is not smooth, check whether the gasoline filter is blocked. If it is blocked by foreign matters, replace it in time. Come to the website for more relevant information http://ablank.cn Contact us for advice!
